Removal Of Solenoid Or Valve Body

1. MAKE PLATE TO RETAIN ACCUMULATOR PISTONS

A retainer is helpful for holding accumulator pistons in the case during removal and installation of the valve body.

The plate may be made from aluminum or plastic.

2. CLEAN TRANSMISSION EXTERIOR

To help prevent contamination, clean the exterior of the transmission.

3. DRAIN TRANSMISSION FLUID

Remove the drain plug and drain fluid into a suitable container.

Transmission Solenoid Toyota Tercel

4. REMOVE OIL PAN, FILLER TUBE AND GASKET

CAUTION: Some fluid will remain in the oil pan. Be careful not to damage the filler tube and O-ring.

Remove all pan bolts, and carefully remove the pan assembly. Discard the gasket.

5. REMOVE OIL TUBES

(a) Remove the four tubes in the numerical order shown.

(b) Pry up both tube ends with a large screwdriver and remove the tubes.

6. DISCONNECT TWO CONNECTORS FROM SOLENOID

(a) Disconnect the solenoid wire from clamp.

(b) Disconnect the two connectors.

AT07J3

7. WHEN REPLACING SOLENOID

(1) Remove the two bolts.

(2) Remove the solenoid.

(1) Remove the three bolts.

(2) Remove the solenoid with gasket.

NOTE: Be careful not to remove the two valve springs.

8. REMOVE OIL STRAINER

Remove the six bolts, and the oil strainer.

CAUTION: Be careful as some oil will come out with the oil strainer.

9. REMOVE VALVE BODY

(a) Remove the fifteen bolts.

(b) Remove the 82 and C2 accumulator piston springs.

Toyota Celica Vacuum Switching Valve

9. REMOVE VALVE BODY

(a) Remove the fifteen bolts.

atq/34

(c) Lower valve body slightly, and install the accumulator piston retaining plate. Hold in place with two pan bolts, finger tight.

\

\ \

W VP v^ft

\

atow

Valve Body Toyota 4runner 1992 Instal

Id) Disconnect the throttle cable from the cam and remove the valve body.

Was this article helpful?

0 0
Simple Car Care Tips and Advice

Simple Car Care Tips and Advice

Put an End to All Your Car Troubles. Does Your Car Break Down Often? Are You Spending More On Fuel Than You Thought You Would? Is Maintaining Your Car Eating Into Your Budget? Make Your Car Last Longer with Some Simple Do It Yourself Tips.

Get My Free Ebook


Responses

  • Mark
    Where drain toyota 2000 avalon transmission fluid?
    8 years ago

Post a comment