Emission Control System

Total OBD & ECU Auto Diagnostics

Total OBD & ECU Auto Diagnostics

Get Instant Access

PARTS LOCATION

Toyota Emissions Parts

2007 ENGINE Emission Control - Sequoia

Fig. 1: Identifying Emission Control System Parts Location (1 Of 2) Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.

Fig. 1: Identifying Emission Control System Parts Location (1 Of 2) Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.

Emission System Parts
AIR SWITCHING VALVE

2007 ENGINE Emission Control - Sequoia

Evap Evaporative Emission Control System
Fig. 3: Evaporative Emission (EVAP) Control System Diagram Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.

ON-VEHICLE INSPECTION

1. VISUALLY CHECK HOSES, CONNECTORS AND GASKETS

a. Check that there are no cracks, leaks or damage.

2007 ENGINE Emission Control - Sequoia

NOTE:

• Detachment or other problems with the engine oil dipstick, filler cap, PCV hose and other components may cause the engine to run improperly.

• Disconnection, looseness or cracks in the parts of the air induction system between the throttle body and cylinder head will allow air suction and cause an engine failure or engine failure malfunctions.

If the result is not as specified, replace parts as necessary.

If the result is not as specified, replace parts as necessary.

Fig. 4: Checking Hoses, Connectors & Gaskets For Leaks Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.

2. CHECK FUEL CUT OFF RPM

a. Start and warm up the engine.

b. Connect intelligent tester.

1. Connect a intelligent tester to the Controller Area Network Vehicle Interface Module (CAN VIM). Then connect the CAN VIM to the Date Link Connector 3 (DLC3).

2007 ENGINE Emission Control - Sequoia

Fig. 5: Connecting CAN VIM To Data Link Connector 3 (DLC3) Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.

c. Inspect fuel cutoff rpm operation.

1. Increase the engine speed to at least 2,500 rpm.

2. Check for injector operating noise.

3. Check that when the throttle lever is released, injector operation noise stops momentarily and then resumes.

HINT:

• The vehicle should be stopped.

2007 ENGINE Emission Control - Sequoia

Fig. 6: Checking That When Throttle Lever Is Released, Injector Operation Noise

Stops Momentarily & Then Resumes

Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.

Fig. 6: Checking That When Throttle Lever Is Released, Injector Operation Noise

Stops Momentarily & Then Resumes

Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.

4. Disconnect the intelligent tester and CAN VIM from the DLC3.

Was this article helpful?

0 0
Do It Yourself Car Diagnosis

Do It Yourself Car Diagnosis

Don't pay hundreds of dollars to find out what is wrong with your car. This book is dedicated to helping the do it yourself home and independent technician understand and use OBD-II technology to diagnose and repair their own vehicles.

Get My Free Ebook


Post a comment